He knew that John Bradford, with whom he was on terms of greater intimacy8 than any other of his neighbors, had a large lot of logs to haul, and that he was the owner of a whip-saw. Leaving the shop, he went over to John's and said to him,—
[Pg 32]
"John, I suppose by this time you've heard all about my blacksmithing."
"Reckon I have, and everybody else in this place. They say you hammer the iron on a lapstone, same as a shoemaker his leather."
"Not quite so bad as that; but I find I must have a pair of bellows, and I want inch-and-a-half stuff to make the 'woods.' I have got a pine log at the door, and I can't go eleven miles to a sawmill; indeed, I don't think I could get there with cattle, the snow is so deep. Will you take your saw, and help me saw out the stuff? and I'll take my oxen and haul logs for you."
"Won't I? I'll be right glad to do it."
"Then I'll go home, and get my log on the saw-pit and come over in the morning."
Two men accustomed to the work will saw out boards and plank9 with a whip-saw as well as they can be sawed in a mill, only it takes more time. Richardson had a place fixed10 near the bank of the river, where the ground fell off abruptly11. Here stringers were laid on uprights set in the ground, on which the log to be sawed was rolled, and the descent of the ground afforded room to work the saw, which is nearly as large as a mill-saw, one man standing12 on top of the log, and the other on the ground below.
With the aid of his neighbor, Richardson not only sawed out plank enough for the woodwork of his bellows, but one to make a bench, and boards[Pg 33] enough to make a door to replace the rude one of poles, and to close a window he meant to make over the bench.
Having procured13 the material for the woods, the next article needed was leather to cover the woods. Putting on his snow-shoes, he tracked and killed a moose, took the hair off with strong lye, then tanned it with salt and alum, and pounded it upon the anvil14 with a stick, kneaded it in his hands, and greased it with the marrow15 of the moose till it was as limp as a rag.
He now made the woods of the bellows, and bows, and as he had neither nails nor tacks16, fastened the skin to the woods with wooden pegs17. All this he accomplished18 without much difficulty; but without iron how was he to make the nose, which must enter the fire, or at least must approach within a few inches of it? The nose of a smith's bellows is of iron, and enters what is called the tuyere pipe, which is in these days quite a complicated affair, and communicates with the fire.
"It's no sort of use, William," said his wife; "it must be iron, and you'll have to go to John Drew, and get him to make it."
"I'll sleep a night on it," was the reply, "before I give it up."
Whether he received any information in dreams, or not, I am unable to say; but this much is evident—that he rose in a hopeful frame of mind,[Pg 34] and, to the great surprise of his wife, whose whole soul was in the matter, set to work without the least hesitation19.
Our readers will recollect5 that swamps in the forest do not freeze to a great depth, and often, when the snow comes before the cold is severe, not at all. Richardson found clay that he could get at in the swamp, and by cutting the ice obtained sand from the bottom of the brook20. He now, with a hoe, broke up all the lumps in the clay, put water to it, and worked it with the hoe till it was fine and tough; then he worked in the sand, made a box a foot square, without ends (by nailing four pieces of boards together), and three feet in length. In the middle of this box he set a pine plug, larger at one end than the other, and tapering21 to the size he thought requisite22, and filled the space between it and the sides of the box with the mixture of clay and sand, ramming23 it hard with his hammer-handle, in order that there should be no hollow places; put it in the kitchen, where it might dry gradually without freezing; made the frame, and hung his bellows on wooden pins, in default of iron; made the pole to blow with, while a strip of moose-hide served instead of a chain to lift the "wood" of the lower bellows; and then went into the woods to haul logs while his clay was drying, which required time, as the box excluded, in a great measure, the air.
In the mean while, work accumulated on his[Pg 35] hands. Reuben Hight brought a chain to be mended, John Bradford a kitchen shovel24, the handle of which was broken in two. These shovels25 were very large, the handle as long as a broom-handle, and the blade nearly as wide as that of a barn shovel. James Potter brought the bail26 of a Dutch oven; John Skillings wanted a hook made to a chain, and brought a harrow tooth to make it of. Richardson promised to do the whole when he got his bellows done, if he could, of which he felt by no means assured.
The clay was now thoroughly27 dried, being kept near the fire, and Richardson put the box on the kitchen hearth28, and built a very moderate fire. This he gradually increased, till the box was burnt, the plug of pine consumed, and the clay brought to the condition of brick. He then permitted the fire gradually to burn out, and, when the operation was over, he had, as the result, a complete cone29, thoroughly burnt. He made a square hole in his butment, put the pipe through it, with the smaller end towards the forge, and bedded it in clay mortar30.
Into the large end of this brick cone he put the wooden nose of his bellows. It being a great deal smaller than the cone, he filled around it with clay mortar; his object in giving this shape to the passage being to admit filling, in order to prevent burning the wooden nose of the bellows. The length of the cone prevented its heating [Pg 36]sufficiently31 to burn the bellows-nose by reason of its great distance from the fire, being out of the stone butment, in the cool air; and the clay mortar around the nose was, he thought, a poorer conductor of heat than the brick cone itself.
Richardson completed his work about noon, and it was a good deal of self-denial to him to abstain32 from making a coal fire at once, and going to work; but he thought it best to let his mortar dry. He, however, satisfied himself that there would be no difficulty in raising all the wind he needed, and he made a small wood fire to dry the clay before it should freeze.
The next morning the shop presented much the appearance of a jubilee33. The children had obtained a promise from their father that he would not kindle2 the fire till they were up. They were out of bed before a ray of light streaked34 the sky, and the moment breakfast was despatched, the whole family, even to the dog and cat, hastened to the shop. It was Saturday, and Richardson, knowing that Bradford's wife would want to bake, and need the shovel, began with that, putting the two parts in the fire, after having made them ready to weld, or, as he termed it, "shut." He resolved to have a heat this time; put on the coal, and plied35 the bellows; but by and by he noticed that the iron began to send off sparks, and saw little black specks36 of charcoal37 sticking to the iron. Pulling it out of the fire, he found it was[Pg 37] all burnt to a honeycomb: that the little black specks of charcoal had burnt into the very substance of the iron, and yet they were black, and the iron came to pieces the moment he struck it. The anvil was covered with scales, and he found it would not weld.
He was sadly puzzled, and most of all, that the charcoal that stuck to the iron, and burnt into it, did not get red hot itself: and he found there was such a thing as getting iron too hot. Little Clem had been to John Drew's with his father in the canoe, and now came to the rescue.
"Father," he said, "why don't you do like as Mr. Drew did?"
"How did he do, child?"
"I seed him stick the iron into sand, and once I seed him poke38 the coal away, and fling the sand right into the fire."
The father now recollected that he had often seen the blacksmith put his iron into sand, but did not know what he did it for. He got some sand, and put the iron into it, then put it into the fire, found the iron did not burn, and he welded it without any more trouble.
He now got along bravely, being able to heat his iron so that it would draw easily. Even the harrow-tooth presented no obstacle; for, after bringing it to a white heat, he got his wife to hold it with the tongs, and using the old axe39 as a sledge40, soon brought the tooth to a size that he[Pg 38] could work with his nail-hammer, and finished his job. As to the bellows, they were a great success, afforded a strong blast, and he found the constant current of cold air passing through the cone kept it from becoming hot enough to burn the nose of the bellows.
"William," said his wife, "I'll never say you can't do anything again."
It may seem strange to our readers that Richardson should be able to heat iron sufficiently to be drawn41 and cut with an axe, and still should have so much difficulty in making it hot enough to weld. They may likewise wish to know what good the sand does.
Iron can be cut and hammered when red hot; but, in order to weld, it must be brought to a white heat—almost melted. When in this state, the two pieces of iron to be united are laid one upon the other, and made to unite by a few smart blows with a hammer. If the operation is rightly performed, the two pieces of iron will become perfectly43 united, and be as strong at the place where they are welded as elsewhere.
It is, however, quite a nice operation to weld thoroughly. Iron, when highly heated, inclines to oxidize rapidly. This forms a scale similar to that which you perceive on iron when it is rusty44. If the two pieces of iron are put together in this condition, these scales that are loose on the iron will prevent the union of the parts. That is the[Pg 39] way iron burns up. It oxidizes, and the iron flies off in sparks that are scales red hot. When the smith sees the iron begin to sparkle, he takes it out of the fire, and rolls it in sand, and then puts it in again, or opens the fire, and sprinkles sand upon it. The sand melts, combines with the oxide45 of iron, and forms silicate46 of iron, spreads over the surface of the iron, protects it, prevents the formation of scales, and when it is struck with the hammer, leaves the surface clean, and the iron unites perfectly, and forms a solid junction47. The smith also leaves the surface of the two pieces to be welded highest in the middle, in order that they may touch there first, and then, when struck with the hammer, the melted sand or oxide will be squeezed out.
The possession of a pair of bellows, with which he was enabled to heat his iron thoroughly, and soften48 it to such a degree that he could work it with his nail-hammer, proved of the utmost service to our persistent49 smith, and he was enabled, by the aid of his wife and the children, to mend chains, staples50 of yokes51, domestic utensils52, and most of the articles his neighbors brought to him, and, as we have seen in the last chapter, was gaining knowledge even by his mistakes.
But there was a good deal of work that would be more profitable than any he had hitherto done that he was compelled to lose for the want of tools. There were oxen to be shod. Four of the[Pg 40] neighbors now kept horses. These they worked before their oxen, and therefore wanted them shod all round, and were obliged to pay John Drew an exorbitant53 price to leave his shop, and come through the woods on snow-shoes to do it. It was quite as important that he should have iron as tools, in order to learn by practice, as he could not expect his neighbors to find iron for him to spoil in learning. To this end he laid by every cent he earned by his blacksmith work, in order with that, the cloth, butter, and linen54 yarn55, to obtain both.
The tools for the lack of which he was the most crippled in his work were a pair of smiths' tongs, a hammer, and a punch. The kitchen tongs were wretched things to hold iron with. It required all his strength to hold a small piece of iron, and the jaws56 were so short that it was constantly slipping; whereas, the handles of a smiths' tongs, being crossed like scissor-blades, act as a lever, and the jaws are long, to hold the iron; while a smiths' hammer, being much heavier, and with a larger face, deals a more effective blow, and is, by its form, adapted to the work. In addition to all this, he had but one pair of kitchen tongs, and when he had to weld two pieces of iron, he made a pair of wooden ones, with which his wife took out one of the pieces of iron, and held it till it was "stuck."
He longed—O, how he longed!—for a little[Pg 41] iron that he could call his own. It consumed him—this desire—even as does the greed of gold a miser57. He reckoned with a piece of charcoal on the top of the bellows the amount of money he had on hand, the cost of getting Drew to make him the tools, and the probable proceeds of the articles he had to sell. To his dismay he found, after purchasing even the few tools he must have, there would remain but a mere42 trifle with which to buy iron.
"I must," he said to himself, "either go without the iron or the tools. No, I won't; I'll make the tools.—I will do it, and save the money to buy iron."
Just then his wife came in to call him to supper, and overheard the remark, but did not, as before, say, "William, you never can do it."
点击
收听单词发音
收听单词发音 |
1
kindled
|
|
| （使某物）燃烧，着火( kindle的过去式和过去分词 )； 激起（感情等）； 发亮，放光 | |
参考例句： |
|
|
|
|
2
kindle
|
|
| v.点燃，着火 | |
参考例句： |
|
|
|
|
3
bellows
|
|
| n.风箱；发出吼叫声，咆哮（尤指因痛苦）( bellow的名词复数 )；（愤怒地）说出（某事），大叫v.发出吼叫声，咆哮（尤指因痛苦）( bellow的第三人称单数 )；（愤怒地）说出（某事），大叫 | |
参考例句： |
|
|
|
|
4
recollected
|
|
| adj.冷静的；镇定的；被回忆起的；沉思默想的v.记起，想起( recollect的过去式和过去分词 ) | |
参考例句： |
|
|
|
|
5
recollect
|
|
| v.回忆，想起，记起，忆起，记得 | |
参考例句： |
|
|
|
|
6
undertaking
|
|
| n.保证，许诺，事业 | |
参考例句： |
|
|
|
|
7
tongs
|
|
| n.钳；夹子 | |
参考例句： |
|
|
|
|
8
intimacy
|
|
| n.熟悉，亲密，密切关系，亲昵的言行 | |
参考例句： |
|
|
|
|
9
plank
|
|
| n.板条，木板，政策要点，政纲条目 | |
参考例句： |
|
|
|
|
10
fixed
|
|
| adj.固定的，不变的，准备好的；(计算机)固定的 | |
参考例句： |
|
|
|
|
11
abruptly
|
|
| adv.突然地，出其不意地 | |
参考例句： |
|
|
|
|
12
standing
|
|
| n.持续，地位；adj.永久的，不动的，直立的，不流动的 | |
参考例句： |
|
|
|
|
13
procured
|
|
| v.（努力）取得， （设法）获得( procure的过去式和过去分词 )；拉皮条 | |
参考例句： |
|
|
|
|
14
anvil
|
|
| n.铁钻 | |
参考例句： |
|
|
|
|
15
marrow
|
|
| n.骨髓；精华；活力 | |
参考例句： |
|
|
|
|
16
tacks
|
|
| 大头钉( tack的名词复数 )； 平头钉； 航向； 方法 | |
参考例句： |
|
|
|
|
17
pegs
|
|
| n.衣夹( peg的名词复数 )；挂钉；系帐篷的桩；弦钮v.用夹子或钉子固定( peg的第三人称单数 )；使固定在某水平 | |
参考例句： |
|
|
|
|
18
accomplished
|
|
| adj.有才艺的；有造诣的；达到了的 | |
参考例句： |
|
|
|
|
19
hesitation
|
|
| n.犹豫，踌躇 | |
参考例句： |
|
|
|
|
20
brook
|
|
| n.小河，溪；v.忍受，容让 | |
参考例句： |
|
|
|
|
21
tapering
|
|
| adj.尖端细的 | |
参考例句： |
|
|
|
|
22
requisite
|
|
| adj.需要的，必不可少的；n.必需品 | |
参考例句： |
|
|
|
|
23
ramming
|
|
| n.打结炉底v.夯实（土等）( ram的现在分词 )；猛撞；猛压；反复灌输 | |
参考例句： |
|
|
|
|
24
shovel
|
|
| n.铁锨，铲子，一铲之量；v.铲，铲出 | |
参考例句： |
|
|
|
|
25
shovels
|
|
| n.铲子( shovel的名词复数 )；锹；推土机、挖土机等的)铲；铲形部份v.铲子( shovel的第三人称单数 )；锹；推土机、挖土机等的)铲；铲形部份 | |
参考例句： |
|
|
|
|
26
bail
|
|
| v.舀（水），保释；n.保证金，保释，保释人 | |
参考例句： |
|
|
|
|
27
thoroughly
|
|
| adv.完全地，彻底地，十足地 | |
参考例句： |
|
|
|
|
28
hearth
|
|
| n.壁炉炉床，壁炉地面 | |
参考例句： |
|
|
|
|
29
cone
|
|
| n.圆锥体，圆锥形东西，球果 | |
参考例句： |
|
|
|
|
30
mortar
|
|
| n.灰浆，灰泥；迫击炮；v.把…用灰浆涂接合 | |
参考例句： |
|
|
|
|
31
sufficiently
|
|
| adv.足够地，充分地 | |
参考例句： |
|
|
|
|
32
abstain
|
|
| v.自制，戒绝，弃权，避免 | |
参考例句： |
|
|
|
|
33
jubilee
|
|
| n.周年纪念；欢乐 | |
参考例句： |
|
|
|
|
34
streaked
|
|
| adj.有条斑纹的，不安的v.快速移动( streak的过去式和过去分词 )；使布满条纹 | |
参考例句： |
|
|
|
|
35
plied
|
|
| v.使用（工具）( ply的过去式和过去分词 )；经常供应（食物、饮料）；固定往来；经营生意 | |
参考例句： |
|
|
|
|
36
specks
|
|
| n.眼镜；斑点，微粒，污点( speck的名词复数 ) | |
参考例句： |
|
|
|
|
37
charcoal
|
|
| n.炭，木炭，生物炭 | |
参考例句： |
|
|
|
|
38
poke
|
|
| n.刺，戳，袋；vt.拨开，刺，戳；vi.戳，刺，捅，搜索，伸出，行动散慢 | |
参考例句： |
|
|
|
|
39
axe
|
|
| n.斧子；v.用斧头砍，削减 | |
参考例句： |
|
|
|
|
40
sledge
|
|
| n.雪橇，大锤；v.用雪橇搬运，坐雪橇往 | |
参考例句： |
|
|
|
|
41
drawn
|
|
| v.拖，拉，拔出；adj.憔悴的，紧张的 | |
参考例句： |
|
|
|
|
42
mere
|
|
| adj.纯粹的；仅仅，只不过 | |
参考例句： |
|
|
|
|
43
perfectly
|
|
| adv.完美地，无可非议地，彻底地 | |
参考例句： |
|
|
|
|
44
rusty
|
|
| adj.生锈的；锈色的；荒废了的 | |
参考例句： |
|
|
|
|
45
oxide
|
|
| n.氧化物 | |
参考例句： |
|
|
|
|
46
silicate
|
|
| n.硅酸盐 | |
参考例句： |
|
|
|
|
47
junction
|
|
| n.连接，接合；交叉点，接合处，枢纽站 | |
参考例句： |
|
|
|
|
48
soften
|
|
| v.(使)变柔软；(使)变柔和 | |
参考例句： |
|
|
|
|
49
persistent
|
|
| adj.坚持不懈的，执意的；持续的 | |
参考例句： |
|
|
|
|
50
staples
|
|
| n.（某国的）主要产品( staple的名词复数 )；钉书钉；U 形钉；主要部份v.用钉书钉钉住( staple的第三人称单数 ) | |
参考例句： |
|
|
|
|
51
yokes
|
|
| 轭( yoke的名词复数 )； 奴役； 轭形扁担； 上衣抵肩 | |
参考例句： |
|
|
|
|
52
utensils
|
|
| 器具，用具，器皿( utensil的名词复数 )； 器物 | |
参考例句： |
|
|
|
|
53
exorbitant
|
|
| adj.过分的；过度的 | |
参考例句： |
|
|
|
|
54
linen
|
|
| n.亚麻布，亚麻线，亚麻制品；adj.亚麻布制的，亚麻的 | |
参考例句： |
|
|
|
|
55
yarn
|
|
| n.纱，纱线，纺线；奇闻漫谈，旅行轶事 | |
参考例句： |
|
|
|
|
56
jaws
|
|
| n.口部；嘴 | |
参考例句： |
|
|
|
|
57
miser
|
|
| n.守财奴，吝啬鬼 (adj.miserly) | |
参考例句： |
|
|
|
| 欢迎访问英文小说网 |